Table of Content

Open Access iconOpen Access

ARTICLE

crossmark

SIMULATION AND INVESTIGATION OF NANO-REFRIGERANT FLUID CHARACTERISTICS WITH THE TWO-PHASE FLOW IN MICROCHANNEL

Ammar Hassan Soheel, Omar Mahmood Jumaah, Ahmed Mustaffa Saleem*

Technical Engineering College, Northern Technical University, Mosul, 41001, Iraq
* Corresponding author. Email: ahmedmustafa@ntu.edu.iq

Frontiers in Heat and Mass Transfer 2021, 17, 1-7. https://doi.org/10.5098/hmt.17.21

Abstract

This paper presents a simulation and investigation of the heat transfer coefficient, pressure drop, and thermal conductivity of two - phase flow. The simulation was performed of mixtures (Al2O3 nanoparticles with R134a refrigerant). The size of nanoparticles (Al2O3) which is used in this study is 30 nm and volume concentrations are 0.015 and 0.03. The two – phase flowing through a horizontal circular microchannel of (diameter 100 µm, and length 20 mm) under constant heat flux (3000 W/m2) and constant wall temperature (330 K), also in this study used the inlet temperature at -20 oC and mass flow rates are 0.3, 0.4, 0.5, 0.6, 0.7 and 0.8 g/s using in the dissipation of heat from electronic circuits by evaporation. The simulation is achieved by CFD numerical model using FLUENT ANSYS version 15 software. The results indicate the best temperature, pressure drop, density and volume fraction for two-phase flow nanorefrigerant in the microchannel. The higher heat transfer coefficient and pressure drop of two-phase nanorefrigerant flow at a high volume concentration (0.03) of Al2O3 when the mass flow rate is maximum. Finally, compared heat transfer coefficient of this study with the results of Kumar et al. (2013) at variation the mass flow rate, and found the root mean square of error (10%), also compared heat transfer coefficient of this study with results of Hernández et al. (2016) at variable volume concentration of nanoparticles Al2O3, and found the root mean square of error (3.7%).

Keywords


Cite This Article

Soheel, A. H., Jumaah, O. M., Saleem, A. M. (2021). SIMULATION AND INVESTIGATION OF NANO-REFRIGERANT FLUID CHARACTERISTICS WITH THE TWO-PHASE FLOW IN MICROCHANNEL. Frontiers in Heat and Mass Transfer, 17(1), 1–7.



cc This work is licensed under a Creative Commons Attribution 4.0 International License , which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
  • 257

    View

  • 279

    Download

  • 0

    Like

Share Link